CROSS US Logo
Menu

Safety information search results

Filter your results

Content type

409 results
Reset filters

Apparently simple home improvement work leads to dangerous situation

Apparently simple home improvement work, consisting of reroofing and a loft conversion, resulted in a 'near miss' with potentially dangerous conditions for neighbours.

21 August 2023

CROSS Safety Report

Report ID: 1173

Region: CROSS-UK

Poorly applied external insulation on buildings

This report concerns external insulation on buildings being inadequately applied and fixed, with poor control of the workmanship standards, leading to potential safety concerns and damage to the property.

21 August 2023

CROSS Safety Report

Report ID: 1203

Region: CROSS-UK

Overloading a portal frame with suspended services

A reporter designing a single storey portal frame used a standard roof service loading of 0.25kN/m2. After the project was completed, a tenant for the unit took over fit out and added a considerable amount of sprinkler pipework into the roof. This created local overloading.

21 August 2023

CROSS Safety Report

Report ID: 1195

Region: CROSS-UK

Incorrectly fixed sheets blow off parapet

This report concerns aluminium coping sheets that blew off the parapet of a block of flats under construction. The reporter says a fierce wind blew off several sheets which fell to the ground about 9m below. A building and a car were damaged but thankfully no one was hurt, although the potential for personal injury or death was significant.

25 May 2023

CROSS Safety Report

Report ID: 1180

Region: CROSS-UK

Concerns over corrosion of dissimilar metals in fixing cavity wall tie systems

A reporter is concerned about corrosion that may occur between dissimilar metals that can be used in cavity wall tie systems. The reporter has noted that stainless steel and carbon steel may be fixed together in wall cavities, which are damp environments, and that corrosion of dissimilar metals in contact may occur.

24 May 2023

CROSS Safety Report

Report ID: 1186

Region: CROSS-UK

Failure to grout steel frame bases

A reporter describes a problem that arose during the construction stage of a project when a steel frame supporting pipe and cable racks was loaded before the frame baseplates were grouted.

24 May 2023

CROSS Safety Report

Report ID: 1190

Region: CROSS-UK

Concern about rebending starter bars

This report concerns the bending and rebending of starter bars on site during the construction of a multi storey tower. The reporter considered that such a practice could compromise the structure under extreme load conditions.

24 May 2023

CROSS Safety Report

Report ID: 1164

Region: CROSS-UK

Incorrectly installed tension control bolts could have led to serious consequences

A reporter finds incorrectly installed system HRC preload bolt assemblies, better known as tension control bolts, during a site inspection of a new highway bridge over a railway. The incorrectly fitted bolts could have had major structural implications, and led to other safety risks, if the installation error had not been spotted.

24 May 2023

CROSS Safety Report

Report ID: 1196

Region: CROSS-UK

Dangerous defects in curtain wall glazing

This report concerns a 5m high vertical glazing system in which the fixings for a panel failed after only four years because of a lack of co-ordination between designers and contractors.

6 April 2023

CROSS Safety Report

Report ID: 762

Region: CROSS-UK

Architectural panel acting as barrier

A reporter came across a scenario on site where an architectural decorative panel was acting as a barrier during the construction stage without being designed to act as one.

6 April 2023

CROSS Safety Report

Report ID: 927

Region: CROSS-UK

Submit a report

Your report will make a difference. It will help to create positive change and improve safety.

Our secure and confidential safety reporting system gives professionals the opportunity to share their experiences to help others.

Find out more